济南富强门业有限公司网站 在线留言 联系我们

服务咨询热线

151 6888 2846

热门关键词: 水晶折叠门 水晶卷帘门 抗风卷帘门

行业新闻

首页>>新闻资讯>>行业新闻
联系我们
济南富强门业有限公司

联系人:林经理

电话:151 6888 2846

邮箱:527800164@qq.com

地址:济南市历下区化纤厂路8号3号楼101号

济南卷帘门常见问题解析

来源:http://www.jnzxmy.com 日期:2025-07-28 发布人:

  济南卷帘门广泛应用于商铺、仓库等场所,长期使用中易受气候和使用习惯影响出现故障。了解这些问题的成因与解决方法,能及时维护,延长使用寿命,避免隐患。

  Jinan rolling shutter doors are widely used in shops, warehouses and other places, and are prone to malfunction due to the influence of climate and usage habits during long-term use. Understanding the causes and solutions of these problems can enable timely maintenance, extend service life, and avoid safety hazards.

  运行卡顿多与轨道和帘片相关。济南春季多风沙,轨道易堆积杂物,导致帘片升降受阻,需用毛刷清理后涂润滑油减少摩擦。轨道垂直度偏差超 3mm/m 会使帘片倾斜卡顿,需用水平仪校准固定。木质卷帘门夏季因高湿度会受潮膨胀,可在接缝处涂蜂蜡并加强通风,避免挤压卡顿。

  The running lag is mostly related to the track and curtain. Jinan is prone to sandstorms in spring, and the track is prone to accumulating debris, which can hinder the lifting and lowering of the curtains. It is necessary to clean with a brush and apply lubricating oil to reduce friction. The deviation of track verticality exceeding 3mm/m will cause the curtain to tilt and jam, and it needs to be calibrated and fixed with a level. Wooden rolling shutter doors may become damp and expand in summer due to high humidity. Beeswax can be applied to the joints and ventilation should be strengthened to avoid compression and jamming.

  电机故障影响电动卷帘门启停。电机不启动可能是电源问题或过热保护(夏季高温易发生),检查电路后若仍不启动,需暂停使用待其冷却。电机有 “嗡嗡” 声不运转,可能是电容损坏(需换同型号)或齿轮箱卡滞(清理油污并加润滑脂)。电机噪音增大多为轴承磨损,需及时更换,冬季低温会使轴承润滑脂凝固,建议入冬前检查。

  Motor malfunction affects the start and stop of electric rolling shutter doors. The motor not starting may be due to power issues or overheating protection (which is prone to occur in high temperatures in summer). If it still does not start after checking the circuit, it is necessary to pause its use and wait for it to cool down. The motor has a buzzing sound and is not running, which may be due to damaged capacitors (need to be replaced with the same model) or stuck gearbox (clean the oil stains and add lubricating grease). The increase in motor noise is mostly due to bearing wear and needs to be replaced in a timely manner. Low temperatures in winter can cause the bearing grease to solidify. It is recommended to check before entering winter.

  帘片损坏需按材质处理。钢制帘片受碰撞易凹陷,小面积可从内侧顶平,大面积变形需更换。济南酸雨会导致钢制帘片锈蚀,初期可打磨涂防锈漆,严重时需换帘片,每半年喷防锈剂预防。PVC 卷帘门冬季易脆化开裂,小裂缝用专用胶修补,大裂缝需贴同材质补丁。

  Damaged curtains need to be treated according to the material. Steel curtains are prone to dents due to collisions, and small areas can be flattened from the inside. Large areas of deformation require replacement. Jinan acid rain can cause rusting of steel curtains. In the initial stage, they can be polished and coated with anti rust paint. In severe cases, the curtains need to be replaced, and anti rust agents should be sprayed every six months to prevent it. PVC rolling shutter doors are prone to brittleness and cracking in winter. Small cracks should be repaired with specialized adhesive, while large cracks require patches of the same material.

20230627051144688

  控制系统故障致操作失灵。遥控失灵可能是电池没电(换 3V 锂电池)或信号干扰,仍失灵可能是接收器故障,需重新配对或更换。手动链条卡顿多因缺油或有异物,清理后加专用润滑油即可。限位开关易因振动移位,导致门体不能完全开关,需调节电机侧面螺丝校准,济南多风易使开关松动,建议每季度检查。

  Control system malfunction leading to operational failure. Remote control failure may be due to low battery (replace with 3V lithium battery) or signal interference. If it still fails, it may be a receiver malfunction and needs to be re paired or replaced. The manual chain may be stuck due to lack of oil or foreign objects. After cleaning, add special lubricating oil. The limit switch is prone to displacement due to vibration, which may cause the door to not fully open and close. It is necessary to adjust the screws on the side of the motor for calibration. The frequent wind in Jinan can cause the switch to loosen, so it is recommended to check it quarterly.

  密封性下降影响隔热防盗。门体与地面间隙超 10mm,可加装 5-8mm 高橡胶密封条,磨损后及时更换。侧边密封毛条脱落需用卡扣固定,老化变硬(阳光直射加速老化)需整体更换。顶部卷轴密封盖松动会进灰尘,需拧紧螺丝,损坏后及时更换以防雨水渗入电机舱。

  The decrease in sealing performance affects thermal insulation and theft prevention. If the gap between the door and the ground exceeds 10mm, a 5-8mm high rubber sealing strip can be installed and replaced in a timely manner after wear and tear. The side sealing strip needs to be fixed with a buckle if it falls off, and it needs to be replaced as a whole if it becomes hard due to aging (accelerated by direct sunlight). Loose sealing cover of the top scroll can attract dust, so it is necessary to tighten the screws and replace them promptly if damaged to prevent rainwater from seeping into the motor compartment.

  济南卷帘门的问题与环境、使用频率相关,日常建议每月清洁轨道、每季度检查电机与链条,每年保养,结合气候提前防护(夏季防高温、冬季防冻),减少故障确保稳定运行。

  The problems with Jinan rolling shutter doors are related to the environment and frequency of use. It is recommended to clean the track every month, check the motor and chain every quarter, conduct comprehensive maintenance every year, and combine climate protection in advance (preventing high temperatures in summer and freezing in winter) to reduce malfunctions and ensure stable operation.

  本文由济南卷帘门友情奉献.更多有关的知识请点击:http://www.jnzxmy.com真诚的态度.为您提供为的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

  This article is a friendly contribution from Jinan Rolling Shutter Doors For more information, please click: http://www.jnzxmy.com Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.

阅读/ Recommended reading

  济南的温带季风气候给卷帘门带来了特殊的锈蚀考验 —— 夏季的高湿度与雨水、冬季的寒风与融雪盐分,再加上春秋季的昼夜温差,使得金属卷帘门的防锈能力面临多重挑战。卷帘门的锈蚀并非均...

济南卷帘门常见问题解析 2025-07-28
济南卷帘门定制所需资料解析 2025-07-25
济南卷帘门使用中的调整要点:适配场景与气候的实用指南 2025-07-24
济南卷面门组成的相关解析 2025-07-22
济南卷帘门常出现的问题有哪些? 2025-07-18
济南卷帘门轨道怎么清洁? 2025-07-16
济南卷帘门具备防火性质的必备条件 2025-07-11
济南卷帘门的安装与拆卸方式方法 2025-07-10